Dale Nelson 38

ENGINES
Two Yanmar 6LY2-STE 420hp turbo charged diesel engines with Micro Commander electronic controls at both helm
stations. These engines have been regularly maintained. The engines are flexibly mounted and sea water filter to each
engine. Automatic fire extinguisher to engine room. Manufacturer’s instrumentation in custom built helm panels.
Port gearbox overhauled 2019. Starboard gearbox overhauled 2019.
STERN GEAR
Four bladed propellors fitted - props x2 rebalanced by specialist 2013.
Sure seals fitted 2013.
Stern tube cooling valves replaced 2015
Replaced all cutlass bearings Nov 2021
STEERING
Dual station hydraulic steering, greasers to rudder tubes, stainless steel emergency tiller.
Rudders - replaced seals - Nov 2021
Hydraulic steering fittings – cleaned off and paint hydraulic fittings on steering pipework - Nov 2021

ELECTRICS
12-volt system
2 engine batteries @ 105amp – sealed type. New batteries fitted 2015.
2 domestic batteries @ 115amp – one sealed one non sealed. New batteries fitted 2015.
Additional batteries fitted to starboard side 2017.
Sealed and vented battery boxes
Cross over battery link switch
Battery voltage meter with two battery bank facility - please note the indicator lights on panels are now redundant - a
Sterlin Proswitch 32 automatic change over control the head unit with indicator lights has been mounted on panel
behind steering wheel.
Ammeter
3 x pantograph windscreen wipers with freshwater washers – Service carried out in 2015
Wheelhouse front screens – electrically heated
12-volt socket to helm area x 2
Many additional lights with dimmer lighting to wheelhouse
Navigation lights
Anchor light
Another Wake Sept23 Page 6 of 9
Horn
Searchlight – handheld with external power point
Magnetic compass at external helm
Stereo radio with speakers to dinette and aft deck
240-volt system
Galvanic isolator fitted to shore supply
Battery charger and distribution system connected to the hot water immersion tank heater and shore power. New
battery charger fitted 2015
240 - volt plug points to cabins, galley, and wheelhouse
240-volt shore power lead - located in aft deck locker
5kw inverter new fitted Feb 2017

12 batterie volts, 240 tension d'alimentation à quai, 4 batterie(s) chargé(s) par: moteur, prise de quai

INTERIOR FINISH
Interior fittings in chrome
American cherry timber and veneer - finished - two pack semi-gloss varnish
Another Wake Sept23 Page 2 of 9
Alcantara to side and overhead linings throughout
Scatter cushions
Carpeted throughout
Carpet inlay to wheelhouse and galley steps
Upholstered seating in dinette and wheelhouse. Re-upholstered 2015
Curtains to wheelhouse
Curtains to all cabins
Grab handles throughout
Grab handles additional to galley forward & outboard of pilot seat in wheelhouse
Interior helm console – upholstered in vinyl
Interior helm and pilot seats including sliders and arm-rests – upholstered in leather
Interior helm steering wheel – covered – TAN colour
Exterior helm steering wheel - Stainless Steel

List of work undertaken by Dale Sailing 2021 – Early 2022:
− Varnished exterior teak badging. Carried out two full coats of varnish to exterior badging - including
companionway doors
− Companionway doors renew chrome fitting on keyway
− New seat base cushions and backs. New black exterior GRP seat covers - specialist upholsterer to fabricate.
− Alcantara - cleaned headlining wheelhouse, forward cabin bunk and linings. Dinette roof panel - fitted new
velcro to aft end of panel.
− Replaced forward and aft heads door mirrors
− Cleaned out lockers forward heads, aft steerage area, aft cabin bilge pump area. Cleaned up rudder tube
greasers
− Replaced blinds to aft cabin rear portlights.
− Free off port forward cabin overhead vent and lubricate all vents
− Replaced port and starboard raw water pumps. Cleaned off and repainted engine mounts and brackets
below water pumps due to seal leak.
− Replaced port and starboard engine cooling water circulation pumps. Cleaned and painted area below
pumps. Topped up coolant
− Serviced/replaced alternator on starboard engine and retest.
− Repaired and refitted Tachometers interior LCDs
− Replaced all cutlass bearings on port and starboard shafts
− Sure seals - removed balance line and relocated flush supply point to exhaust water injection hose
− Replaced 2x seal rudders
− Cleaned off and painted hydraulic fittings on steering pipework due to surface rust above and below the
rudder shelf
− Fitted 1x new Rule 2000 bilge pump with auto operations to starboard engine room
− Fitted new gas solenoid valve in deck locker.
− Unblock black tank pick up
− Replaced trim tab and shaft anodes
− Carried out fire extinguisher test throughout boat
− New offshore flares kit
− Fitted aft cabin mattress
− Exterior stainless steel and GRP - cleaned off staining to davits etc
− Topsides – cleaned and power polish. Applied 2x coats of UV wax
− Superstructure – clean and power polish. Applied 2x coats of UV wax
− Fitted 2x sliding windows – sliding front to back
− Re-routed battery cables and secured battery in box
− Cleaned and refitted Nav light – port and starboard
− Fitted new hatch in shower
− Fitted new hoses to black waste system from skin fitting to toilet, from toilet to black waste tank and from
tank to outlets.
− Fitted new “one piece” fabric screen internal cover complete with storage back
− Fitted 2x new anode studs to both sides including new terminals.
− Fitted 2x new hull anodes
List of Work Undertaken late 2022
− Both propellers re-balanced.
Another Wake Sept23 Page 9 of 9
List of work Undertaken 2023
− Both engines serviced, oils and filters changed.
− Generator serviced.
− Anodes checked and changed where necessary.
− Collapsible support fitted for chart table to be used in wheelhouse.
− Hull antifouled, 2 coats.
− Hull and topsides polished.
− Liferaft serviced.
− Epirb Registered.
− Gas solenoid fitted in deck locker.
− 2 Camping Gaz cylinders and regulator fitted.

FORWARD HEADS
Wash basin, mixer tap with hot and cold pressurised water
Shower
Manual toilet
Toilet connection to waste tank
Lockers
Towel rail
Additional hanging hooks fitted
Standard door from galley/dinette to heads not fitted

Aft Heads
Wash basin, mixer tap with hot and cold pressurised water
Shower
Electric toilet
Toilet connection to waste tank
Lockers
Towel rail
Stainless steel shaving mirror – replaced new mirror for forward and aft heads Nov 2021

2 feux(s) gaz cuisinière